91 Or 92 Exciter Ii Tors Problems - Snowmobile World : Your #1 Snowmobile Forum
http://www.snowmobileworld.com/forums
» Sponsors
Go Back   Snowmobile World : Your #1 Snowmobile Forum > SNOWMOBILING SECTION > YAMAHA

Reply
 
Thread Tools
Old 05-15-2005, 11:14 AM   #1
Thundercat96
Senior Member
 
Join Date: Dec 2003
Location: MI
Primary Sled: 96 thundercat
Where I sled: mid michigan
Posts: 229
Default

hey fella's i have a 91 or 92 exciter II and i'm having some problems OK here we go if i put 2 new plugs in her and start her up she runs fine but if i give it a little bit of gas the tors light comes on and the the right cylinder fowls the plug. and the left runs stays running, But if i put another new plug in it and start it up then give it all the gas both cylinders run until you let off of the throttle then the tors light comes back on and she fowls the right cylinder again can anyone please help very frustrating. thanks allen.
Thundercat96 is offline   Reply With Quote
Sponsored Links
Advertisement
 
Old 05-15-2005, 06:57 PM   #2
shortstop20
Senior Member
 
shortstop20's Avatar
 
Join Date: Sep 2004
Primary Sled: '98 Yamaha SRX 700
Where I sled: Stickney, South Dakota
Posts: 308
Default

Not sure on the fouling plug issue, but I would disconnect your tors. It causes nothing but problems on the Exciters.
shortstop20 is offline   Reply With Quote
Old 05-15-2005, 08:05 PM   #3
Thundercat96
Senior Member
 
Join Date: Dec 2003
Location: MI
Primary Sled: 96 thundercat
Where I sled: mid michigan
Posts: 229
Default

Quote:
Originally posted by shortstop20@May 15 2005, 07:57 PM
Not sure on the fouling plug issue, but I would disconnect your tors.* It causes nothing but problems on the Exciters.
[snapback]420459[/snapback]
where do you unplug it at and do you think that has something to do with the fouling have you ever heard of that before or no.
Thundercat96 is offline   Reply With Quote
Old 05-15-2005, 08:10 PM   #4
Octane
Senior Member
 
Octane's Avatar
 
Join Date: Dec 2004
Location: Edgerton/St Germain, Wisconsin
Mileage: 900 miles
Primary Sled: '01 Polaris 600 EDGE X
Where I sled: St Germain, WI
Posts: 526
Default

Yamaha has had problems with the TORS for years. Im not sure how you go about bypassing it but I would find out how and do it.
Cap'n
Octane is offline   Reply With Quote
Old 05-18-2005, 11:33 AM   #5
Bluehaze
Senior Member
 
Bluehaze's Avatar
 
Join Date: Nov 2004
Location: 42.53.250N 088.12.703W el. 764ft (give or take)
Mileage: zero miles
Primary Sled: 1996 Yamaha V-Max 600 DX
Where I sled: WI
Posts: 411
Default

I have not had problems with my TORS (yet). Are you saying that more than likely I will??

I just picked up my Yammie in April, and have not given it a ride yet. Is this something I should be looking into as well?
__________________
"Life should NOT be a journey to the grave
with the intention of arriving safely
in an attractive and well-preserved body,
but rather to skid in sideways,
chocolate in one hand,
martini in the other,
body thoroughly used up,
totally worn out and screaming...

"WOO HOO what a ride!"
Bluehaze is offline   Reply With Quote
Old 05-19-2005, 10:34 PM   #6
shortstop20
Senior Member
 
shortstop20's Avatar
 
Join Date: Sep 2004
Primary Sled: '98 Yamaha SRX 700
Where I sled: Stickney, South Dakota
Posts: 308
Default

Thundercat96,
There will be a harness that is plugged into your carbs(I think it's plugged into the carbs, don't remember for sure?)

Bluehaze,
I think you will be ok if you leave it hooked up on your '96 V-max 600. I haven't heard of any problems on the V-max's. There may be some, but as I said, I haven't heard of any. If you do experience any fuel related problems I would unhook it and see it that makes a difference in performance. If not, I say leave it as is.

my .02
shortstop20 is offline   Reply With Quote
Old 05-20-2005, 08:28 AM   #7
Bluehaze
Senior Member
 
Bluehaze's Avatar
 
Join Date: Nov 2004
Location: 42.53.250N 088.12.703W el. 764ft (give or take)
Mileage: zero miles
Primary Sled: 1996 Yamaha V-Max 600 DX
Where I sled: WI
Posts: 411
Default

Quote:
Originally posted by shortstop20@May 19 2005, 11:34 PM
Bluehaze,
I think you will be ok if you leave it hooked up on your '96 V-max 600.* I haven't heard of any problems on the V-max's.* There may be some, but as I said, I haven't heard of any.* If you do experience any fuel related problems I would unhook it and see it that makes a difference in performance.* If not, I say leave it as is.*

my .02
[snapback]420897[/snapback]


Thanks, I'll watch for this coming season.
__________________
"Life should NOT be a journey to the grave
with the intention of arriving safely
in an attractive and well-preserved body,
but rather to skid in sideways,
chocolate in one hand,
martini in the other,
body thoroughly used up,
totally worn out and screaming...

"WOO HOO what a ride!"
Bluehaze is offline   Reply With Quote
Old 06-19-2005, 07:40 PM   #8
seancrazy1
Senior Member
 
seancrazy1's Avatar
 
Join Date: Dec 2004
Location: Southern Maine
Mileage: 215
Primary Sled: 97 arctic cat Z 440
Where I sled: southern maine
Posts: 203
Send a message via AIM to seancrazy1 Send a message via Yahoo to seancrazy1
Default

Hey, I have a Vmax-4, and the tors light came on when the carbs got messed up. The gas throttle cable is seperate from oil throttle cable, and the oil cable got stuck open. ( this is on my Vmax4. ) The 2 right cylinders kept getting flooded and fouling the the plugs. After it did that, it would shut the sled down. I suggest you oil your cables, and rebuild the carb/carbs.
__________________
EXTREME FILMS - www.extremefilms.frih.net

SLEDS AND QUADS FOR SALE:

1988 Yamaha Inviter 300 - Engine is out of sled. Needs water pump impeller. Hood has hole/crack in very front of it. Engine has BRAND NEW wiesco piston and rings. Needs new track.
$110 obo

1997 Arctic Cat Z 440 - GREAT SHAPE! Sled needs nothing, and is good to go. No cracks on the sled. Track is in great shape. No tears in the seat. Under 1900 miles on sled. $1900 firm

2001 Suzuki LTf 160 - Quad is nice. New chain. 5spd. Great starter quad. $700

$2500 takes it all.

seancrazy1 is offline   Reply With Quote
Old 07-08-2005, 10:01 AM   #9
kimo
Senior Member
 
kimo's Avatar
 
Join Date: Aug 2004
Location: Kuujjuaq
Primary Sled: Pro X 2 800, 2001 ZR 800, MXZX 440 LC
Where I sled: Kuujjuaq, QC
Posts: 137
Default

Not snowmobile related, but Yamaha related, had a problem with my tors on my banshee.

i was riding in the rain, hit a bump and my quad died out, it would start but when i would give it gas it would die out.

i disconnected the tors quad ran fine after; on the quad their was a little black box near the carbs with a wire coming out of it. unplugged that wire, had no problems since.
kimo is offline   Reply With Quote
Old 09-18-2005, 10:30 PM   #10
#1 yamaha
Junior Member
 
Join Date: Sep 2005
Location: Jackson, MN: originally Mayville, ND
Primary Sled: 1992 Yamaha Exciter II
Where I sled: North Dakota, Minnesota
Posts: 11
Default

I have owned a 1992 Exciter II LE since fall of 1996, so 9 years. I have not had any problems with it. Mine has done it a couple of times when it was really cold out and I rode in some really deep soft powder. The carbs froze up for a second and the TORS kicked in.

I know on the Phazer II's there was a wire under the hood back by the steering column that had two separate conections on it. If you unplugged them and plugged them and then plugged the right side ones into each other and the left ones into each other you would bypass the TORS system but everything else would still work.

As for the flooding of the right cylinder, I would say that your right carb is not adjusted right. The slide is not seating all the way down when the throttle is at an idle. I would say you need to adjust your throttle cable and slide in your carb so that when you let off the throttle the slide hits the bottom of its stroke when the throttle bottoms out. This should also fix the problem with the TORS because it is looking for a difference in slide positioning between the right and left carb. If you get the carbs adjusted so they both start to move at the same time and at the same rates you should be fine.
#1 yamaha is offline   Reply With Quote
Sponsored Links
Advertisement
 
Reply

Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Powered by vBadvanced CMPS v3.2.2

All times are GMT -5. The time now is 02:07 AM.



Powered by vBulletin® Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.